clocktrio.blogg.se - Vwvortex launchcontrol

#VWVORTEX LAUNCHCONTROL HOW TO#
#VWVORTEX LAUNCHCONTROL DRIVER#
#VWVORTEX LAUNCHCONTROL MANUAL#
#VWVORTEX LAUNCHCONTROL CODE#

*SPEC Lightweight Flywheel Stage 2 Clutch Installed*

SPEC has clutch/flywheel packages for MkV GTI.

The United States NHTSA Opens A Federal Investigation Into DSG Failures: Clutch See also: DSG: problem with hard engagement from stops (Group: 35, Number: 06-01, 2004-2006 New Beetle, New Jetta, Golf GTI with DSG)

"Another inexpensive DSG fluid fill tool" : DIY DSG filler, using a DSG fill adapter and a pressurized garden sprayer.

Installing OSIR shift knob & boot : removing stock shift knob & boot.

Part V DSG Transmission Service: Technical Procedure.

Part IV DSG Transmission Service (Mechanical Procedure).

Part III DSG Transmission Service (Mechanical Procedure).

Part II Performing the DSG Transmission Service (Mechanical Procedure).

Part I DSG (02E) Transmission - 40,000 miles maintenance service.

DSG (02E) Transmission - 40,000 miles maintenance service, on :.

More info on changing DSG oil, including part numbers of oil, filter, and seal.

#VWVORTEX LAUNCHCONTROL HOW TO#

How to change DSG transmission oil: procedure & illustrations.

New seal for drain plug: # N 910 845 01, about $2.

DSG transmission filter: # 02E 305 051 B, about $50.

DSG transmission fluid: # G 052 182 A2, about $20 per liter, x 6 = $120.

Parts needed for DSG transmission oil change:.

The transmission needs to be removed, then the rivets drilled on a drill press, to separate the diff from the transmission. The stock one-way differential is riveted to the transmission.

Peloquin's TBD (Torque Biasing Device), more commonly know as a LSD, for the MkV GTI.

Short shift kit by Jose at JS Performance.

Dieselgeek short shifter for the MkV GTI.

Shifting into 'S' only changes the DSG's behavior and does not change the engine's behavior.

Differences between Euro and US DSG (also available here: DSG-FAQ.html).

The TSB involves flashing the Mechatronics Unit firmware using CD W42DQ250RD2." " VWoA has issued TSB 37 06 06, dated 8 December 2006, to enable Launch Control on ALL 2007 model year Jetta GLIs and GTIs with DSG transmissions that were not factory enabled.

"The 02E Direct Shift Gearbox, Design and Function".

#VWVORTEX LAUNCHCONTROL CODE#

The first time i ever did do LC i accidentally had the Hand brake still on as i took off but that didnt seem to affect me doing it numerous times after that.The transmission code for the 2.0T's 6-speed transmission is 02Q (zero two Q). Made sure wheel was perfectly centered, even drove for a distance in a dead straight line stopped and started LC setup, still nothing. Ground looked relatively flat even tried on different areas of the stretch of road would be very surprised if the whole length of it was considered too steep of incline for LC.

Took it out again this arvo to try, Operating temp looked good Drove for 15min sat with it on and revved it a little here and there for another 10 to make sure it was nice and warm.Īmbient temp was ok at about 20degrees Celsius (About 68F) so was most likely warmer than the day i did get it working. Yeah have taken all those into consideration. Has anyone had the same issue or know of anything about this?Ĭlick to expand.Hey mate cheers for reply,īy anychance could you link me to the places you've seen/heard about people having the same issue? PM if you'd like. The only thing im thinking that could possibly be the problem is that the operating tempt wasnt optimum but i had been driving it for about 15min prior so surely that wasn't the issue as it was also a warmish day and the temp needle was at the halfway point. Turned car off then on again did the whole procedure again.

I have tried in different modes, Normal, Sport andTrack (didnt try drift) Still nothing. "LC" appears on the dash indicating its now activated, rev the car but it just doesn't hold at 5000 rpm anymore it just goes all the way to 6-6.5ish before i take off my foot before i break something.

#VWVORTEX LAUNCHCONTROL DRIVER#

Using the menus, setting, driver assist, launch control selected.

#VWVORTEX LAUNCHCONTROL MANUAL#

consulted the manual followed the procedure step by step. thought maybe i was doing something wrong. I used it the other day for the first time and had no issues used it about 4 times before calling it a day.Ībout 1-2 weeks later i tried to show the girl friend and it just wouldn't work. Has anyone else experienced issues with their launch control?